coolant problem
 

Had trouble with coolant leaking drained it now I got air lock problem how can I fix it.Thanks Tony

Re: coolant problem
 

Anybody have any ideas.Thanks Tony

Re: coolant problem
 

Hey people anybody got any ideas.Thanks Tony

Re: coolant problem
 

Hey Tony,
the best and most efficient way is to run the car with the coolant cap off or if it starts spraying up then leave the cap on but unscrew it so you circulate some air through there. It is a lengthy process but it works. and then keep doing that and adding coolant

Re: coolant problem
 

Thanks seems I always wait for your dependable reply.Thanks again Tony and have a great christmas.

Re: coolant problem
 

NP.... Just be careful as it will get really hot... you can squeeze it out a bit faster by pressing and releasing the hoses that run to the rad...once again be careful as they get hot as well. Or you can take it to your local shop and they will charge you and undo the airlock obviously as some might suggest! The car will get hot so keep an eye on the temp gauge and make sure you don't go over the 90 temp zone as it will stick your thermostats.

Re: coolant problem
 

Here is the tools you need for refilling it looks like a little flange and screws onto the cap this is for a B6 I would ask for a b5

Screw adapter VAG1274/8 onto coolant expansion tank.
Fit special tool VAG1274/10 onto adapter.
Fill cooling system with coolant.
Seal expansion tank.
Start engine and maintain engine speed of approx. 2000 RPM for approx. 3 minutes.
Allow engine to run at idling speed until lower hose on radiator becomes hot.
CAUTION!
Hot steam can escape when cap on expansion tank is opened. Cover cap with cloth and open carefully.

Check coolant level and top off if necessary.
When engine is at normal operating temperature, coolant level must be at max. mark.
When engine is cold, coolant level must be between min. and max. marks.
Switch off engine.

Re: coolant problem
 

Worked out fine thanks also the pipe that goes across in front of the motor at the oil pan it has the Y at the end is leaking coolant maybe rusted out any way I can subsitute with a hose.Seem its awful hard to get out its right above the ac hoses any suggestions.Thanks so much Tony

Re: coolant problem
 

I would have to look at it I am not sure about this issue as I am not that familiar with B5's! Sorry Tony

Re: coolant problem
 

No problem if you can find out would be great if not no problem.Thanks Tony