94 Audi 90 CS - failed emission test - Cat Converter?
#1
Guest
Posts: n/a
94 Audi 90 CS - failed emission test - Cat Converter?
I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
first mistake).
Anyway, it failed the emission test in Ohio with very high NOx
readings. CO and HC were in very acceptable ranges. I was told it is
probably the catalytic converter. Well unfortunately, I think the car
has two cat converters and they run around $300 each.
Does anyone have any experience with the universal catalytic
converters (which run about $90 each) and getting them installed in a
90 CS? Any problems with these and integrating into the exhaust
system?
Does anyone have any other thoughts besides replacing the cat conv to
reduce NOx emissions? I already changed oil, changed plugs, changed
anti-freeze and air filter. None of this helped NOx, reduced CO and
HC a bit, but NOx actually went up.
--
Posted using the http://www. interface, at author's request
Articles individually checked for conformance to usenet standards
Topic URL: http://www./Audi-94-90...ict129675.html
Visit Topic URL to contact author (reg. req'd). Report abuse: http://www./eform.php?p=631989
first mistake).
Anyway, it failed the emission test in Ohio with very high NOx
readings. CO and HC were in very acceptable ranges. I was told it is
probably the catalytic converter. Well unfortunately, I think the car
has two cat converters and they run around $300 each.
Does anyone have any experience with the universal catalytic
converters (which run about $90 each) and getting them installed in a
90 CS? Any problems with these and integrating into the exhaust
system?
Does anyone have any other thoughts besides replacing the cat conv to
reduce NOx emissions? I already changed oil, changed plugs, changed
anti-freeze and air filter. None of this helped NOx, reduced CO and
HC a bit, but NOx actually went up.
--
Posted using the http://www. interface, at author's request
Articles individually checked for conformance to usenet standards
Topic URL: http://www./Audi-94-90...ict129675.html
Visit Topic URL to contact author (reg. req'd). Report abuse: http://www./eform.php?p=631989
#2
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
bwm wrote:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
High NOx does indicate bad catcon.
Aftermarket ones are available - I'm not sure I'd want to trust a
system to a cheapy universal, but more toward an AM one from a
reputable Audi parts supplier, with brand names like Bosal or Stromung.
A high-mileage Audi will serve you well, as long as you keep on top of
those small things. A well-kept older Audi can keep it's resale value
for a long time, even with high miles - as long as you keep it in
tip-top shape. Let it go, and you'll be looking at a valueless
money-pit.
Now for the embarrassing question: why didn't you get a pre-purchase
inspection done? No matter what brand of used car, this is an
essential step. Once you found out about the bad catcons, you could
have negotiated a better price to cover the cost of replacement.
Still, unless you spent WAY over blue book, even with the bad catcons,
I think you'll find that used Audis provide a lot of bang for your
used-car buck.
Good luck, and report back when you get her fix up.
E.P.
#3
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
bwm wrote:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
High NOx does indicate bad catcon.
Aftermarket ones are available - I'm not sure I'd want to trust a
system to a cheapy universal, but more toward an AM one from a
reputable Audi parts supplier, with brand names like Bosal or Stromung.
A high-mileage Audi will serve you well, as long as you keep on top of
those small things. A well-kept older Audi can keep it's resale value
for a long time, even with high miles - as long as you keep it in
tip-top shape. Let it go, and you'll be looking at a valueless
money-pit.
Now for the embarrassing question: why didn't you get a pre-purchase
inspection done? No matter what brand of used car, this is an
essential step. Once you found out about the bad catcons, you could
have negotiated a better price to cover the cost of replacement.
Still, unless you spent WAY over blue book, even with the bad catcons,
I think you'll find that used Audis provide a lot of bang for your
used-car buck.
Good luck, and report back when you get her fix up.
E.P.
#4
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
bwm wrote:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
High NOx does indicate bad catcon.
Aftermarket ones are available - I'm not sure I'd want to trust a
system to a cheapy universal, but more toward an AM one from a
reputable Audi parts supplier, with brand names like Bosal or Stromung.
A high-mileage Audi will serve you well, as long as you keep on top of
those small things. A well-kept older Audi can keep it's resale value
for a long time, even with high miles - as long as you keep it in
tip-top shape. Let it go, and you'll be looking at a valueless
money-pit.
Now for the embarrassing question: why didn't you get a pre-purchase
inspection done? No matter what brand of used car, this is an
essential step. Once you found out about the bad catcons, you could
have negotiated a better price to cover the cost of replacement.
Still, unless you spent WAY over blue book, even with the bad catcons,
I think you'll find that used Audis provide a lot of bang for your
used-car buck.
Good luck, and report back when you get her fix up.
E.P.
#5
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
bwm,
Mistake? 181k miles is not a heck of a lot - what matters if they were "hard
or easy" miles - aka - how faithful the previous owner(/s) was to the
maintenance schedule of the car.
How old are the plug wires? How old is/are the oxygen sensors?
When the e-test is run, the car should be at operating temperature - that
means that you should take it out and drive around for a while, then take it
to the test facility and do the test without letting the car cool down. If
the cats are cool - the car has sat for hours before the test and only run
briefly before the start of the test, the elements will not have heated up
enough and will not be working.
Cheers!
Steve Sears
1987 Audi 5kTQ
1980 Audi 5k
1962 and '64 Auto Union DKW Junior deLuxes
(SPAM Blocker NOTE: Remove SHOES to reply)
"bwm" <UseLinkToEmail@> wrote in message
news:1_631989_b2bcf7f940538fca319cc996de5c8dd3@aut oforumz.com...
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
>
> --
> Posted using the http://www. interface, at author's request
> Articles individually checked for conformance to usenet standards
> Topic URL:
http://www./Audi-94-90...ict129675.html
> Visit Topic URL to contact author (reg. req'd). Report abuse:
http://www./eform.php?p=631989
Mistake? 181k miles is not a heck of a lot - what matters if they were "hard
or easy" miles - aka - how faithful the previous owner(/s) was to the
maintenance schedule of the car.
How old are the plug wires? How old is/are the oxygen sensors?
When the e-test is run, the car should be at operating temperature - that
means that you should take it out and drive around for a while, then take it
to the test facility and do the test without letting the car cool down. If
the cats are cool - the car has sat for hours before the test and only run
briefly before the start of the test, the elements will not have heated up
enough and will not be working.
Cheers!
Steve Sears
1987 Audi 5kTQ
1980 Audi 5k
1962 and '64 Auto Union DKW Junior deLuxes
(SPAM Blocker NOTE: Remove SHOES to reply)
"bwm" <UseLinkToEmail@> wrote in message
news:1_631989_b2bcf7f940538fca319cc996de5c8dd3@aut oforumz.com...
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
>
> --
> Posted using the http://www. interface, at author's request
> Articles individually checked for conformance to usenet standards
> Topic URL:
http://www./Audi-94-90...ict129675.html
> Visit Topic URL to contact author (reg. req'd). Report abuse:
http://www./eform.php?p=631989
#6
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
bwm,
Mistake? 181k miles is not a heck of a lot - what matters if they were "hard
or easy" miles - aka - how faithful the previous owner(/s) was to the
maintenance schedule of the car.
How old are the plug wires? How old is/are the oxygen sensors?
When the e-test is run, the car should be at operating temperature - that
means that you should take it out and drive around for a while, then take it
to the test facility and do the test without letting the car cool down. If
the cats are cool - the car has sat for hours before the test and only run
briefly before the start of the test, the elements will not have heated up
enough and will not be working.
Cheers!
Steve Sears
1987 Audi 5kTQ
1980 Audi 5k
1962 and '64 Auto Union DKW Junior deLuxes
(SPAM Blocker NOTE: Remove SHOES to reply)
"bwm" <UseLinkToEmail@> wrote in message
news:1_631989_b2bcf7f940538fca319cc996de5c8dd3@aut oforumz.com...
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
>
> --
> Posted using the http://www. interface, at author's request
> Articles individually checked for conformance to usenet standards
> Topic URL:
http://www./Audi-94-90...ict129675.html
> Visit Topic URL to contact author (reg. req'd). Report abuse:
http://www./eform.php?p=631989
Mistake? 181k miles is not a heck of a lot - what matters if they were "hard
or easy" miles - aka - how faithful the previous owner(/s) was to the
maintenance schedule of the car.
How old are the plug wires? How old is/are the oxygen sensors?
When the e-test is run, the car should be at operating temperature - that
means that you should take it out and drive around for a while, then take it
to the test facility and do the test without letting the car cool down. If
the cats are cool - the car has sat for hours before the test and only run
briefly before the start of the test, the elements will not have heated up
enough and will not be working.
Cheers!
Steve Sears
1987 Audi 5kTQ
1980 Audi 5k
1962 and '64 Auto Union DKW Junior deLuxes
(SPAM Blocker NOTE: Remove SHOES to reply)
"bwm" <UseLinkToEmail@> wrote in message
news:1_631989_b2bcf7f940538fca319cc996de5c8dd3@aut oforumz.com...
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
>
> --
> Posted using the http://www. interface, at author's request
> Articles individually checked for conformance to usenet standards
> Topic URL:
http://www./Audi-94-90...ict129675.html
> Visit Topic URL to contact author (reg. req'd). Report abuse:
http://www./eform.php?p=631989
#7
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
bwm,
Mistake? 181k miles is not a heck of a lot - what matters if they were "hard
or easy" miles - aka - how faithful the previous owner(/s) was to the
maintenance schedule of the car.
How old are the plug wires? How old is/are the oxygen sensors?
When the e-test is run, the car should be at operating temperature - that
means that you should take it out and drive around for a while, then take it
to the test facility and do the test without letting the car cool down. If
the cats are cool - the car has sat for hours before the test and only run
briefly before the start of the test, the elements will not have heated up
enough and will not be working.
Cheers!
Steve Sears
1987 Audi 5kTQ
1980 Audi 5k
1962 and '64 Auto Union DKW Junior deLuxes
(SPAM Blocker NOTE: Remove SHOES to reply)
"bwm" <UseLinkToEmail@> wrote in message
news:1_631989_b2bcf7f940538fca319cc996de5c8dd3@aut oforumz.com...
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
>
> --
> Posted using the http://www. interface, at author's request
> Articles individually checked for conformance to usenet standards
> Topic URL:
http://www./Audi-94-90...ict129675.html
> Visit Topic URL to contact author (reg. req'd). Report abuse:
http://www./eform.php?p=631989
Mistake? 181k miles is not a heck of a lot - what matters if they were "hard
or easy" miles - aka - how faithful the previous owner(/s) was to the
maintenance schedule of the car.
How old are the plug wires? How old is/are the oxygen sensors?
When the e-test is run, the car should be at operating temperature - that
means that you should take it out and drive around for a while, then take it
to the test facility and do the test without letting the car cool down. If
the cats are cool - the car has sat for hours before the test and only run
briefly before the start of the test, the elements will not have heated up
enough and will not be working.
Cheers!
Steve Sears
1987 Audi 5kTQ
1980 Audi 5k
1962 and '64 Auto Union DKW Junior deLuxes
(SPAM Blocker NOTE: Remove SHOES to reply)
"bwm" <UseLinkToEmail@> wrote in message
news:1_631989_b2bcf7f940538fca319cc996de5c8dd3@aut oforumz.com...
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
>
> Anyway, it failed the emission test in Ohio with very high NOx
> readings. CO and HC were in very acceptable ranges. I was told it is
> probably the catalytic converter. Well unfortunately, I think the car
> has two cat converters and they run around $300 each.
>
> Does anyone have any experience with the universal catalytic
> converters (which run about $90 each) and getting them installed in a
> 90 CS? Any problems with these and integrating into the exhaust
> system?
>
> Does anyone have any other thoughts besides replacing the cat conv to
> reduce NOx emissions? I already changed oil, changed plugs, changed
> anti-freeze and air filter. None of this helped NOx, reduced CO and
> HC a bit, but NOx actually went up.
>
> --
> Posted using the http://www. interface, at author's request
> Articles individually checked for conformance to usenet standards
> Topic URL:
http://www./Audi-94-90...ict129675.html
> Visit Topic URL to contact author (reg. req'd). Report abuse:
http://www./eform.php?p=631989
#8
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
The message <1_631989_b2bcf7f940538fca319cc996de5c8dd3@autofor umz.com>
from bwm <UseLinkToEmail@> contains these words:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
My 94 100 Avant's got nearly ¼million on it - hardly run in.
--
Skipweasel.
Ivor Cutler - "Never knowingly understood."
from bwm <UseLinkToEmail@> contains these words:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
My 94 100 Avant's got nearly ¼million on it - hardly run in.
--
Skipweasel.
Ivor Cutler - "Never knowingly understood."
#9
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
The message <1_631989_b2bcf7f940538fca319cc996de5c8dd3@autofor umz.com>
from bwm <UseLinkToEmail@> contains these words:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
My 94 100 Avant's got nearly ¼million on it - hardly run in.
--
Skipweasel.
Ivor Cutler - "Never knowingly understood."
from bwm <UseLinkToEmail@> contains these words:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
My 94 100 Avant's got nearly ¼million on it - hardly run in.
--
Skipweasel.
Ivor Cutler - "Never knowingly understood."
#10
Guest
Posts: n/a
Re: 94 Audi 90 CS - failed emission test - Cat Converter?
The message <1_631989_b2bcf7f940538fca319cc996de5c8dd3@autofor umz.com>
from bwm <UseLinkToEmail@> contains these words:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
My 94 100 Avant's got nearly ¼million on it - hardly run in.
--
Skipweasel.
Ivor Cutler - "Never knowingly understood."
from bwm <UseLinkToEmail@> contains these words:
> I recently purchased a 1994 Audi 90 CS with 181000 miles (probably my
> first mistake).
My 94 100 Avant's got nearly ¼million on it - hardly run in.
--
Skipweasel.
Ivor Cutler - "Never knowingly understood."